Livestock Research for Rural Development 32 (2) 2020 LRRD Search LRRD Misssion Guide for preparation of papers LRRD Newsletter

Citation of this paper

Broiler performance on a diet containing palm kernel meal fermented with Bacillus subtilis

Mirnawati, Gita Ciptaan and Ferawati

Department of Animal Nutrition and Feed Technology, Faculty of Animal Science, University of Andalas, Padang 25163, Indonesia
mirnawati@ansci.unand.ac.id

Abstract

This study was done to evaluate the incorporation in broiler diets of palm kernel meal fermented with Bacillus subtilis (FPKM). Day-old chicks (n=140) were allocated to 5 treatments with 4 replications in a completely randomized design. The treatments were increasing levels of FPKM: 0, 15, 20, 25 and 30% in the diet.

Feed intake, body weight gain, nitrogen retention and crude fiber digestibility were reduced with linear or curvilinear trends as the level of FPKM was increased. However, the absolute changes over the range of values from 0 to 25% FPKM were relatively small and it is concluded that palm kernel meal after fermentation with Bacillus subtilis can be used up to 25% in broiler diets with minimal loss of performance and with 50% saving in soybean meal

Keywords: byproducts, fermentation, local resources, oil palm


Introduction

Indonesia, as the largest crude palm oil (CPO) producer in the world, produced 23,096,541 tonnes in 2015 (Directorate General of Plantation 2017). CPO and palm kernel production increase every year along with that there is also an increase in byproducts from the production process of palm kernel oil, namely palm kernel meal (PKM).The proportion of PKM is approximately 45-46% of the palm kernel meal (Sindu 1999). PKM production in 2017 was almost 3.2 million tonnes (Pasaribu 2018).The high production of PKM is a factor that can support its use as alternative feed ingredient for poultry. The proximal analysis of palm kernel meal is: dry matter 87%, crude protein 16%, crude fat 8.2%, crude fiber 21%, Ca 0.27% and P 0.94% (Mirnawati et al 2010).

Palm kernel meal has high potential to be used as poultry feed, but normally is limited to 10% in broiler rations (Rizal 2006). The limiting factor of palm kernel meal utilization especially for monogastric livestock is the high crude fiber content of which around 56% is dominated as β-mannan (Daud et al 1993).The low usage is due to the digestive tract of poultry does not produce β-mannan-breaking enzymes. In order to improve the nutrient quality of palm kernel meal, fermentation with mananolytic fungi can be done (Mirnawati et al 2012; Mirnawati et al 2013).

Fermenting palm kernel meal with mananolytic molds namely Sclerotium rolfsii with 7 days fermentation time and 10% inoculum dose gave the best results with an increase in CP content, in N retention and in digestibility of crude fiber (Mirnawati et al 2017). In a subsequent study it was found that the FPKM produced by fermentation with Sclerotium rolfsii mold could be used up to 25% in broiler rations (Mirnawati et al 2018).

Bacillus subtilis is one of the micro-organisms that are mananolytic (Jiang et al 2006). Bacillus subtilis is often used as a probiotic to help balance beneficial bacteria in the digestive tract (Iman et al 2012). Bacillus subtilis has anti- microbial resistance and can produce anti-microbial properties, so that these bacteria can survive in the digestive tract of chicken (Barbosa et al 2005). Fermenting PKM with Bacillus subtilis at a dose of 7% and 6 days fermentation time gave the best results, seen from the crude protein content of 24.7%, nitrogen retention of 68.5%, crude fiber content 17.45 and activities of mannanase, cellulase, protease respectively 6.27 U/ml, 16.11 U/ml and 10.27 U/ml (Mirnawati et al 2019).

From the above data it is seen that the nutrient content of PKM fermented with Bacillus subtilis is sufficient for it to be considered as an alternative feed ingredient for poultry. However, biological tests of this feed ingredient are needed to determine the limits of use and its effect on poultry, especially broilers.


Methodology

Purpose of the experiment

This experiment aimed to study the effect of several levels of palm kernel meal fermented with Bacillus subtilis on the performance of broilers.

Experimental animal and diet composition

One hundred and forty day-old chicks (DOC) Lohmann strain MB-202 Platinum from PT. Japfa Comfeed Indonesia, were assigned to this experiment. The five treatments in a completely randomized design were levels of 0 15, 20, 25 and 30% of FPKM) with four replications. There were seven broilers per experimental unit kept in a box cage (80 x 80 x 60cm). The diets were formulated with 22% protein. Feed ingredients consisted of yellow maize, soybean meal, fermented palm kernel meal (FPKM), fish meal, coconut oil and premix of vitamins-minerals (Tables 1 and 2). Feed and drinking water were provided ad-libitum.

Preparing FPKM

Fermented palm kernel meal was the product of 80% PKM plus 20% rice bran that was fermented with Bacillus subtilis. The dose of inoculum of Bacillus subtilis was 7% of the substrate incubated for 6 days. After harvesting the product, FPKM was dried, milled and mixed in the diets.

Data collection

Feed intake, weight gain, feed conversion, carcass percent, abdominal fat percent, nitrogen retention and crude fiber digestibility were measured.

Data analysis

Data were processed by analysis of variance for a completely randomized design, followed by the test for the differences between treatments, according to Steel and Torrie (2002).

Table 1. Composition of diets

Feed Ingredients

FPKM in diet, %

0

15

20

25

30

Commercial feed

15

15

15

15

15

Yellow maize

45

37.5

35

32.3

29.6

Soybean meal

23

15.2

12.6

10.2

7.7

FPKM

0

15

20

25

30

Fish meal

15

15

15

15

15

Coconut oil

1.5

1.5

19

15

15

Vitamin mix

0.5

0.5

0.5

0.5

0.5



Table 2. Proximate analysis of the diets (% in DM)

FPKM in diet, %

0

15

20

25

30

Crude protein

22.1

22.0

22.0

22.1

22.1

Crude fat

4.09

4.46

4.58

4.70

4.92

Crude fiber

2.83

5.05

5.79

6.53

7.27

Ca

1.22

1.16

1.14

1.12

1.11

Available P

0.64

0.63

0.62

0.61

0.61


Results

Feed intake, growth rates, feed conversion and carcass yield

Performance traits (feed intake, weight gain, feed conversion and carcass yield) showed negative curvilinear trends with little change over the replacement range 0-25% of FPKM. The point of inflexion appeared to be at 25% FPKM, with loss of performance being apparent when the FPKM reached 30% (Table 3; Figures 1-4). The negative effect of the highest level of FPKM was especially evident in the response curve for feed conversion (Figure 3).

Table 3. Mean values for growth and carcass traits of broilers fed increasing levels of FPKM

FPKM in diet, %

SEM

p

0

15

20

25

30

Feed intake, g/wk

530a

529a

527a

527a

520b

3.96

0.05

LW gain, g/wk

284a

283a

281a

280a

271b

4.98

0.01

Feed conversion#

1.88

1.92

1.90

1.91

2.17

0.12

0.01

Carcass, % of LW

70.36a

70.35a

70.33a

70.24a

69.97b

0.16

0.01

Abdomen fat, %

1.66

1.64

1.63

1.61

1.58

0.03

0.01

N retention, %

58.36a

58.06a

57.79a

57.37a

54.14b

1.71

0.01

CF digestibility, %

50.21a

50.08a

49.79a

49.51a

47.87b

0.95

0.01

ab Mean values in the same row without common superscript differ at p<0.05
# Feed intake/LW gain



Figure 1. Effect of level of FPKM on feed intake Figure 2. Effect of level of FPKM on weight gain




Figure 3. Effect of FPKM on feed conversion Figure 4. Effect of FPKM on carcass yield
Digestibility and N retention

The trends in diet digestibility and N retention followed that for body weight gain with the inflection point occurring at about the 25% FPKM level with increased rate of decline in these criteria when the FPKM level was 30% of the diet (Table 3; Figures 5 and 6).

Figure 5. Effect of FPKM on crude fiber digestibility Figure 6. Effect of FPKM on N retention
Abdomen fat

There was a slightly curvilinear reduction in abdomen fat percentage as the level of FPKM increased (Figure 7) mirroring the slight decline in production traits.

Figure 7. Effect of level of FPKM on abdominal fat in the carcass


Discussion

The constraints to use of higher proportions of FPKM in the diet almost certainly are the high levels of fiber in this feed. In this context, future research could consider the use of carbohydrate sources with lower levels of fiber. Cassava root has less fiber than maize and using it to replace maize would also enable lower levels of protein in the diet as maize protein is seriously imbalanced in essential AA.


Conclusions


Acknowledgement

This study was financially supported by funds provided by BOPTN of Andalas University, number 42/UN.16.17/PP.RGB/LPPM/2019, dated April, 23rd 2019. I would like to thank all of those with whom I have had the pleasure to work during this project.


References

Barbosa T M, Serra C R, La Ragione R M, Woodward M J and Hariques A O 2005 Screening of Bacillus isolates in the broiler gastrointestinal tract. Appl. Environ. Microbial. 71 (2): 968-978. https://www.ncbi.nlm.nih.gov/pmc/articles/PMC546680/ doi: 10.1128/AEM.71.2.968-978.2005

Daud M J, Jarvis M C and Rasidah A 1993 Fibre of PKC and its potential as poultry feed. Proceeding. 16th MSAP Annual. Conference, Kuala Lumpur, Malaysia. http://agris.fao.org/agris-search/search.do?recordID=MY9505008

Direktorate Generale Plantation 2017 Statistik Perkebunan Indonesia. Kelapa Sawit. Departemen Pertanian, Jakarta. http://ditjenbun.pertanian.go.id/?publikasi=buku-statistik-kelapa-sawit-palm-oil-2011-2013.

Iman E R S, Mahendra I and Utomo R B 2012 Uji kepekaan Bacillus subtilis yang diisolasi dari sedimen tambak udang dan tambak ikan terhadap bahan antimikroba.Media Veterinaria Medika. Unair, Surabaya. Vol. 5 No. 3. http://journal.unair.ac.id/downloadfull/VetMed6165-73349f453dfullabstract.pdf

Jiang Z, Wei Y, Li D, Li L, Chai P and Kusakabe I 2006 High-level production, purification and characterization of a thermostable-mannanase from the newly isolated Bacillus subtilis WY34. Carbohydrate Polymers, 30:1-9. https://www.sciencedirec.com 1753. https://www.ncbi.nlm.nih.gov/pubmed/24864284

Mirnawati, Ciptaan G and Ferawati 2017 The effect of mannanolytic fungi and humic acid dosage to improve the nutrient contentand quality of fermented palm kernel cake. International Journal of Chem Tech Research. 10(2): 56-61.www.sphinxsai.com

Mirnawati, Ciptaan G and Ferawati 2019 Improving the quality and nutrient content of palm kernel cake through fermentation with Bacillus subtilis. Livestock research for Rural Development. 31(7). http://www.Irrd.org/Irrd31/7/mirna31098.html

Mirnawati, Djulardi A and Ciptaan G 2018 Utilization of fermented palm kernel cake with Sclerotium rolfsii in broiler ration. International Journal of Poultry Science. 17(7): 342-347. http://scialert.net.archivedetails

Mirnawati, Djulardi A and Marlida Y 2013 Improving the quality of palm kernel cake through fermentation by Eupeniciliumjavanicumas poultry ration. Pakistan Journal of Nutrition. 12(12): 1085-1088. http://scialert.net.archivedetails

Mirnawati, Kompiang I P and Suslina A L 2012 Effect of substrate composition and inoculum dosage to improve quality of palm kernel cake fermented by Aspergillus niger. Pakistan Journal of Nutrition. 11(5): 434-438. http://scialert.net.archivedetails

Mirnawati, Rizal Y, Marlida Y and Kompiang I P 2010 The role of humic acid in palm kernel cake fermented by Aspergillus niger for poultry ration. Pakistan Journal of Nutrition. 9(2): 182-185. http://scialert.net.archivedetails

Pasaribu T 2018 Upaya meningkatkan kualitas bungkil inti sawit melalui teknologi fermentasi dan penambahan enzim untuk unggas. WARTAZOA Vol. 28 No. 3. Hal 119-128.http://dx.doi.org/10.14334/wartazoa

Rizal Y 2006 Ilmu Nutrisi Unggas. Andalas University Press. Padang.

Sindu A 1999 Pemanfaatan limbah kelapa sawit sebagai pakan ternak. Jurnal Sains dan Teknologi Indonesia. Vol. 1, No. 3 hal 82-86.

Steel R J dan Torrie J H 2002 Prinsip dan Prosedur Statistik. PT. Gramedia Pustaka Utama, Jakarta.


Received 22 November 2019; Accepted 22 December 2019; Published 1 February 2020

Go to top