Livestock Research for Rural Development 29 (6) 2017 Guide for preparation of papers LRRD Newsletter

Citation of this paper

A low concentration of rice distillers’ byproduct, or of brewers’ grains, increased diet digestibility and nitrogen retention in native Moo Lath pigs fed ensiled banana pseudo-stem (Musa spp) and ensiled taro foliage (Colocasia esculenta)

Bounlerth Sivilai and T R Preston1

Department of Livestock and Fisheries, Faculty of Agriculture, National University of Laos, Vientiane Capital, Lao PDR
lerth_si@yahoo.com
1 Centro para la Investigación en Sistemas Sostenibles de Producción Agropecuaria (CIPAV), Carrera 25 No 6-62 Cali, Colombia

Abstract

Six native Moo Lath pigs with initial live weight of 29.3 kg, fed a basal diet of (DM basis) ensiled banana pseudo-stem (10%), ensiled Taro foliage (70%) and broken rice 20%, were allocated to a 3*3 double Latin Square Design in which the treatments were (DM basis): 4% of brewers’ grains (BG), 4% of rice distillers’ by product (RDB) or no supplement (CTL). The feeds were offered at 3% of live weight (DM basis).

Both supplements improved feed intake, digestibility and N retention, with indications of greater responses in N retention and in the biological value of the protein, for the rice distillers’ byproduct. It is suggested that the beneficial effect of both supplements may have been due to the presence of β-glucan, a component of the cell wall of both cereal grains and yeasts, that is known to have immunological, health-benefitting effects in humans and animals.

Key words: forages, indigenous breeds, prebiotics


Introduction

Brewers' grains have been widely used as protein supplements in diets of pigs and cattle. However, recent research (Binh et al 2017) suggests that they may also provide other benefits, as a source of "prebiotics". The evidence for this idea is from an experiment in which cattle were fed a basal diet of cassava pulp-urea and either sweet (low-HCN) or bitter (high-HCN) cassava foliage as the bypass protein supplement. Growth rate was only 30 g/day with bitter cassava foliage compared with 600 g/day for sweet cassava foliage; and urine thiocyanate excretion was twice as high for the bitter compared with sweet cassava foliage. However, when 4% brewers’ grains were added to the bitter cassava diet, the growth rate increased to 500g/day and urine thiocyanate was reduced by half. It was concluded that the effect of the small supplement of brewers' grains was to assist the immune system in the detoxification of the HCN (Binh et al 2017).

Further evidence for a "prebiotic" effect of a yeast-fermented grain byproduct is: (i) in the report of Vor Sina et al (2017) that supplementing 4% of brewers' grains to goats fed cassava foliage doubled the weight gain from 80 to 160 g/day and reduced urinary excretion of thiocyanate; and (ii) of Sengsouly and Preston (2016) of a 100% increase in growth rate of Yellow cattle fed ensiled cassava root, urea and cassava foliage when the diet was supplemented with 4% rice distillers' byproduct (Quilao), the residue from yeast fermentation of rice to make “ rice wine”. The dramatic improvement in growth rate from supplementation with 4% brewers' grains or "Quilao" cannot be explained as being due to improved supply of nutrients.

The above experiences were the basis of the hypothesis that small amounts (4% of diet DM) of either brewers' grains or rice distillers' byproduct (Quilao) would support increased growth rate in local Moo Lath pigs.


Materials and methods

Location and climate

The experiment was conducted in the livestock farm of the Faculty of Agriculture, National University of Laos, Vientiane Capital, Lao PDR, from 14 September to 31 November, 2016. The average daily temperature during the experiment was 27 ˚C (range from 24 to 30 ˚C). The site of experiment was located 32 km to the south of Vientiane city.

Treatments and experimental design

Six pigs (Moo Lath breed) with average initial live weight of 29.3 kg were individually housed in metabolic cages (Photo 1) and randomly allocated to 3 diets:

CTL: Ensiled banana pseudo stem, ensiled taro foliage and broken ric.

BG: CTL + 4% of brewers' grains

RDB: CTL + 4% of rice distillers' byproduct.

The treatments were arranged according to a double 3*3 Latin Square Design with periods of 10 days: 5 days for adaptation to the change of diet and 5 days for measurement of feed intake and collection of feces and urine.

 

Photo 1. Metabolism cages for feces and urine collection

Feeding management

The control diet was a mixture (DM basis) of 10% ensiled banana pseudo-stem, 70% ensiled taro foliage and 20% broken rice. Rice distillers' by-product and brewers' grain were added at the 4% level (DM basis) to the BG and RDB treatments. Feeding times were 7:00 am and 4 pm. Feed offer level was 3% of live weight (as DM). Water was supplied automatically through nipple drinkers.

Feed resources

The banana pseudo-stem (left over after harvest of the fruit) was brought from the gardens of villagers surrounding the experimental area. Taro foliage (leaves + petioles) was harvested from the banks of ponds in the local village where waste water was stored. Broken rice was purchased from a rice mill in Vientiane capital. Rice distillers’ by-product was purchased from households in the nearby village. Fresh (ensiled) brewers' grains were purchased from a feed shop in Vientiane city (the source was a local brewery).

The inner part of the banana stem was chopped by hand into small sizes around 1-2 cm of length (Photo 2). Taro foliage (leaves and petioles) was processed by machine into particles of 0.5 cm. Both forages were wilted under black netting for a day to reduce moisture content to about 80%, and then stored in closed polyethylene bags for 7-14 days, prior to mixing with the broken rice and supplements (Photos 3 and 4).

Photo 2. Chopped banana pseudo-stem

Photo 3. Rice distillers' byproduct

Photo 4. Brewers' grains

Data collection

Amounts of feed offered and refused were recorded daily and sub-samples retained for analysis (stored at -20˚C). Urine and feces of each pig were collected every morning, were weighed and samples (20 % of total) stored at -20 ºC. Urine was collected in a bucket via a funnel below the metabolism cage with 50ml of 30% H2SO4 to maintain pH below 4. At the end of each experimental period, the daily collections of urine were bulked and representative samples were stored at -20 ºC. The feces collections were also mixed and representative samples dried at 70ºC for 48 h.

Chemical analysis

The samples of feeds, offered and refused, and feces were analyzed for dry matter (DM), nitrogen (N), crude fiber (CF) and ash according to AOAC (1990) methods. The pH of the mixed feed was measured with an electronic meter. Urine was analyzed for N (AOAC 1990).

Statistical analysis

The data were analyzed using the general linear model in the ANOVA program of the MINITAB software (Minitab 2014). Sources of variation were treatments, pigs, periods and error.


Results and discussion

Chemical composition of diets

The values for proximate constituents of brewers’ grains, rice distillers’ byproduct, banana pseudo-stem and Taro silage (Table 1) were in accordance witt those in the literature (Feedipedia.org; Luu Huu Manh et al 2003; Manh et al 2009). The crude protein in the broken rice (12.3%) was higher than the average (10.2%), but within the range of values (7.8-13.2% in DM), reported in Feedipedia.org. The low pH of the brewers’ grains and rice distillers’ by-product indicates that both products were well preserved.

Table 1. Proximate composition of diet ingredients

Diets

DM, %

% in DM

pH

CP

Ash

OM

CF

Brewers’ grains

24.1

23.5

17.6

96.4

16.1

3.28

Rice distillers’ by-product

16.8

22.3

13.9

96.6

3.71

3.21

Ensiled banana pseudo stem

9.93

2.94

1.56

98.4

35.7

4.11

Ensiled taro foliage

10.8

17.2

3.28

96.7

30.0

3.77

Broken rice

88.5

12.3

2.68

97.3

3.00

-



Table 2. Composition of diets (DM basis)

% DM basis

CTL

BG

RDB

Brewers’ grain

0

4

0

Rice distillers’ byproduct

0

0

4

Ensiled taro foliage

70

66

66

Ensiled banana pseudo stem

10

10

10

Broken rice

20

20

20

Proximate analysis, % in DM, except for DM which is on air - dry basis

Dry matter#

12.3

14.1

13.1

Crude protein#

12.6

12.9

12.9

Crude fiber

18.8

18.3

18.4

Ash

1.9

2.0

1.9

Organic matter

98.2

98.0

98.1

pH

3.92

4.00

3.93

# Average of 18 samples of complete feeds offered during the experiment

Feed intake

DM intake was increased 19 and 29%, respectively, by inclusion of BG and RDB in the diets (Table 3; Figure 1). The crude protein in the diet DM consumed (12.6-12.9%) was only slightly higher than was found to be optimum (12% in DM) in an earlier experiment with a similar basal diet (Sivilai and Preston 2017).

Table 3. Mean values for DM intake and % CP of the diet consumed by Moo Lath pigs without (CTL) or with supplements of BG or RDB

CTL

BG

RDB

SEM

p

DM intake, g/d

703b

777a

805a

13.4

<0.001

CP in DM, %

13.1

13.2

13.1

0.07

0.411

ab Mean values within rows with different superscript differ at P<0 . 05

Apparent digestibility

Apparent digestibility coefficients for DM, organic matter, crude fiber and crude protein were increased by both supplements (Table 4; Figures 2-4). The highest relative increases were for crude fiber (8.4 and 11.6 %, respectively for BG and RDB).

Table 4. Mean values for apparent digestibility by Moo Lath pigs fed diets without (CTL) or with supplements of BG or RDB

CTL

BG

RDB

SEM

p

Apparent digestibility, %         

Dry matter

84.5b

87.5a

89.6a

0.84

<0.001

Crude protein

75.6b

79.4ab

80.7a

1.41

0.032

Crude fiber

79.5b

86.2a

88.7a

1.11

<0.001

Organic matter

84.7b

87.8a

89.9a

0.81

<0.001

ab Mean values within rows without common superscript differ at P<0.05



Figure 1. Effect of rice distillers’ by-product and brewers’
grain on DM intake by Moo Lath pigs
Figure 2. Effect of rice distillers’ byroduct and brewers’ grain on
apparent digestibility of DM by Moo Lath pigs
 
 
Figure 3. Effect of rice distillers’ byproduct and brewers’ grain on
apparent digestibility of crude protein by Moo Lath pigs
Figure 4. Effect of rice distillers’ byproduct and brewers’ grains on
apparent digestibility of crude fiber by Moo Lath pigs
Nitrogen balance

N intake and N retained was greater on the BG and RDB diets as a consequence of the increases in DM intake induced by the supplements (Table 5). When the N retained was corrected for differences in N intake, there was no advantage from supplementation with BG; however, the RDB supplement increased N retention by 11% (Table 5; Figure 5). The N retained as a percent of N digested, indicating the biological value of the protein, was increased by both BG and RDB (Table 5; Figure 6).

Table 5. Mean values for N balance by Moo Lath pigs fed diets with or without (CTL) supplements of BG or RDB

CTL

BG 4 %

RDB 4 %

SEM

p - value

N balance, g / d

Intake

14.5b

16.2a

16.7a

0.28

<0.001

Feces

3.2

3.4

2.9

0.19

0.196

Urine

2.2b

2.1b

1.5a

0.10

0.174

N retained

g/day

9.00a

10.7b

12.3c

0.35

<0.001

g/day#

10.2a

10.3a

11.3b

0.27

<0.001

% of digested N

73.8a

83.1b

87.2b

1.91

<0.001

ab Mean values within rows with different superscripts are different at P<0.05
# Corrected by covariance for differences in N intake



Figure 5. Effect of rice distillers’ byproduct and brewers’ grains on N
retention (#corrected by covariance for differences in N intake)
Figure 6. Effect of rice distillers’ byproduct and brewers’
grains on N retention as percent of N digested


Discussion

Previous research with brewers‘ grains (eg: Amaefule et al 2006) and rice distillers’ byproduct (Luu Huu Manh et al 2003) have used these supplements in pig diets as sources of protein replacing conventional protein sources such as fish meal. As far as we are aware, this is the first report on the use of these supplements at low levels in the context, not of sources of protein per se, but as sources of prebiotics (Fuller 1989; Vanbelle et al 1990). Thus in our experiment the diets were compounded to contain the same amount and source of protein, shown previously to be optimum for a diet based on ensiled banana stem and Taro foliage (Sivilai and Preston 2017).

It is suggested that the effect of both brewers’ grains and rice distillers’ byproduct, in supporting improved feed intake, digestibility and N retention, could be explained by the presence in both the supplements of β-glucan, a carbohydrate component of the cell wall of cereal grains and fungi including yeasts. The beneficial effect of β-glucan on growth rate and health in weaning pigs was recently reported by Nguyen Thi Thuy (2017). The immune-modulating effects of β-glucans, with beneficial health effects in humans and animals are well known (see Novak and Vetvicka 2008; Waszkiewicz-Robak 2013).

Brewers’ grains

Barley has been reported to contain β-glucan, on average at 40 g/kg (Havrlentová and Kraic 2006); and 1 kg of barley, processed for production of beer, is estimated to give a residue (brewers’ grains) of 0.6 kg. The concentration of β-glucan in brewers’ grains could then be of the order of 70 mg/g DM. In 1 kg of diet fed to the pigs, there were 40 g of brewers’ grains, that could contain 2.8 g of β-glucan thus the diet fed to the pigs would have contained a maximum concentration of 2.8 g glucan/kg DM. This is similar to the level of “extracted” β-glucan fed to weaning pigs by Nguyen Thi Thuy (2017), with reported increases in growth rate of the order of 10%. Thus 4% of brewers’ grains in the diet may be a reasonable indicator of the amount needed to promote benefits to the animal’s immune system leading potentially to better growth performance.

Rice distillers’ byproduct

Rice distillers’ byproduct is almost always made from milled rice which at most contains 4% crude fiber so rice cell wall fiber is unlikely to contribute more than a minimum amount of β-glucan to the diet supplemented with rice distillers’ byproduct. However, rice distillers’ byproduct is rich in yeast (Dang Thiep, personal communication) and yeast cell walls are reported to contain 7.7% β-glucan (Waszkiewicz-Robak 2013). The report by this author that bakers’ yeast (Saccharomyces cerevisiae) was as effective as pure preparations of β-glucan in reducing cholesterol levels in mice fed a “cholesterol-inducing” diet, lends support to the idea that in rice distillers’ byproduct, it is the yeast that is responsible for the apparent prebiotic effect.


Conclusion


Acknowledgement

This research was done by the senior author as part of the requirements for the PhD degree in Animal Science of Hue Univerity of Agriculture and Forestry, Vietnam. The authors acknowledge support for this research from the MEKARN II project (Improving Livelihood and Food Security of the people in Lower Mekong Basin through Climate Change Mitigation) financed by Sida/MEKARN II. Special thanks are given to students (Mr. Phutthakone Boualavong, Mr. Keo Singsavanh, Mr. Viengxay Khampuvong, Khamlar Khounnavong and Douagsay Xaiyear) for their assistant in field work and laboratory assist during experiment. The Faculty of Agriculture, National University of Laos is acknowledged for providing the facilities to carry out this research.


References

Amaefule K U, Okechukwu S O, Ukachukwu S N , Okoye F C and Onwudike O C 2006 Digestibility and nutrient utilization of pigs fed graded levels of brewers' dried grain based diets. Livestock Research for Rural Development. Volume 18, Article #5.Retrieved April 22, 2017, from http://www.lrrd.org/lrrd18/1/amae18005.htm

AOAC 1990 Official Methods of Analysis: Association of Official Analytical Chemists. 15th Edition. Washington, DC. UAD Arlington pp 1230

Binh Phuong Le Thuy, Preston T R, Duong Nguyen Khang and Leng R A 2017 A low concentration (4% in diet DM) of brewers’ grains improves the growth rate and reduces thiocyanate excretion of cattle fed cassava pulp-urea and “bitter” cassava foliage. Livestock Research for Rural Development. Volume 29, Article #104 http://www.lrrd.org/lrrd29/5/phuo29104.html

Fuller R 1989 Probiotics in man and animals. Journal of Applied Bacteriology. 66(5):365-78.

Havrlentová M and Kraic J 2006 Content of β-D-glucan in cereal grains. Journal of Food and Nutrition Research Volume. 45, 2006, No. 3, pp. 97-103

Luu Huu Manh, Nguyen Nhut Xuan Dung and Lindberg J E 2003 Effects of replacement of fish meal with rice distiller’s waste (hem) on performance and carcass quality of growing pigs In: Proceedings of Final National Seminar-Workshop on Sustainable Livestock Production on Local Feed Resources (Editors: Reg Preston and Brian Ogle). HUAF-SAREC, Hue City, 25 – 28 March, 2003. Retrieved June 28, 2016, from http://www.mekarn.org/sarec03/manh3.htm

Manh L H, Xuan Dung N N, Kinh L V, Binh T C, Thu Hang B P and Phuoc T V 2009 Composition and nutritive value of rice distillers’ by-product (hem) for small-holder pig production.Livestock Research for Rural Development. Volume 21, Article #224. Retrieved February 2, 2017, from http://www.lrrd.org/lrrd21/12/manh21224.htm

Minitab 2014 Minitab reference Manual release 16 version. User’s guide to statistics. Minitab Inc. USA

Nguyen Thi Thuy 2017 Effects of β-glucan, organic acid and probiotic in the diets on growth performance and health status of weaning pigs. Livestock Research for Rural Development. Livestock Research for Rural Development.Volume 29, Article #124. http://www.lrrd.org/lrrd29/6/nthi29124.html

Novak M and Vetvicka V 2008 Beta-glucans, history and the present: Immunomodulatory aspects and mechanisms of action. Journal of Immunotoxicology; 5: 47-57

Sengsouly P and Preston T R 2016 Effect of rice-wine distillers’ byproduct and biochar on growth performance and methane emissions in local “Yellow” cattle fed ensiled cassava root, urea, cassava foliage and rice straw.Livestock Research for Rural Development.Volume 28, Article #178.Retrieved April 22, 2017, from http://www.lrrd.org/lrrd28/10/seng28178.html

Sivilai B and Preston T R 2017 Effect of level of dietary protein on growth and feed conversion of Moo Lath pigs fed a mixture of ensiled taro foliage (Colocasia esculenta) and of ensiled banana pseudo-stem (Musa spp). Livestock Research for Rural Development. Volume 29, Article #34. http://www.lrrd.org/lrrd29/2/boun29034.htm

Vanbelle M, Teller E and Focant M 1990 Probiotics in animal nutrition: a review. Archiv fur Tierernahrung Jul; 40(7):543-67.

Vor Sina, Preston T R and Thâm Hô Thanh 2017 A small supplement of brewers’ grains (4% of the diet) doubled the growth rate, and reduced urinary thiocyanate excretion, of goats fed fresh cassava foliage (Mantihot esculenta Crantz) as the sole diet. Submitted to “ Livestock Research for Rural Development”

Waszkiewicz-Robak B 2013 Spent brewer’s yeast and beta-glucans isolated from them as diet components modifying blood lipid metabolism disturbed by an atherogenic diet (Chapter 11). In: Lipid Metabolism. Editor: Rodrigo Valenzuela Baez, Publisher: InTech, January 23, 2013 under CC BY 3 .0 License. DOI: 10.5772/2928 https://www.intechopen.com/books/lipid-metabolism/spent-brewer-s-yeast-and-beta-glucans-isolated-from-them-as-diet-components-modifying-blood-lipid-me


Received 10 February 2017; Accepted 20 May 2017; Published 1 June 2017

Go to top